混凝土攪拌機可以廣泛的應用在大型建筑工程中，例如公路、橋梁、水利等，并且是一種效率非常高的設備。今天小編就帶大家仔細的了解以下混凝土攪拌機的操作注意事項。

Concrete mixer can be widely used in large construction projects, such as roads, bridges, water conservancy, and is a very efficient equipment. Today, Xiaobian will take you to carefully understand the following precautions for concrete mixer operation.

1、攪拌機周圍要用支架支撐，并且將攪拌機放在堅固的地方。

1. The mixer shall be supported by supports around it and placed in a solid place.

2、攪拌機在使用前要行檢查，確保設備控制器和各部件完好以后才可以正常運行。攪拌機的筒內不能存在異物，否則會影響到后面的攪拌效果。

2. The mixer shall be checked before use to ensure that the equipment controller and components are in good condition before normal operation. There shall be no foreign matters in the barrel of the mixer, otherwise the mixing effect will be affected.

3、攪拌機在進料斗升起的時候，為了起見，禁止人員通過或停留在料斗下方；攪拌機在運行時，不能將工具深入到攪拌筒內。

3. When the mixer is raising the feed hopper, for safety reasons, it is forbidden for personnel to pass or stay under the hopper; When the mixer is running, do not put the tools into the mixing drum.

4、如果現場需要維修，需要將攪拌機的料斗固定好，斷電以后才可以進行維護。如果要進入到攪拌筒內，外面則需要有人員看管。操作人員須持證上崗，禁止將混凝土機械交給無證人員操作，作業時應集中精力，正確操作，不得擅自離崗。

4. If maintenance is required on site, the hopper of the mixer shall be fixed, and maintenance can only be carried out after the power is cut off. If you want to enter the mixing drum, you need someone to watch outside. The operator must hold a certificate to work. It is forbidden to hand over the concrete machinery to an unlicensed person for operation. During operation, the operator should concentrate on correct operation and not leave the post without authorization.

5、作業前應檢查攪拌機的固定、離合器、制動器、滑輪、鋼絲繩、傳動裝置、上料斗限位、電氣線路、保護接零或接地線等，如有異常須排除。

5. Before operation, check the fixation, clutch, brake, pulley, wire rope, transmission device, hopper limit, electrical circuit, protective neutral or grounding wire of the mixer, and eliminate any abnormality.

6、升起上料斗后，料斗下方嚴禁人員進入，清理料斗下方時，須掛上保險鏈，攪拌桶內有人進入清理和維修作業時，應拉下開關箱內的隔離開關，鎖好開關箱，以免誤操作傷人。

6. After the hopper is raised, no one is allowed to enter under the hopper. When cleaning the hopper, safety chains must be hung. When someone enters the mixing bucket for cleaning and maintenance, pull down the isolating switch in the switch box and lock the switch box to avoid injury caused by misuse.

作業完畢，應將機械清理干凈，切斷電源，鎖好開關箱。很重要，所以您在使用該設備進行施工時就要多注意了，更多相關內容就來我們網站http://www.jiyini.cn咨詢吧！

After the operation, the machinery shall be cleaned, the power shall be cut off, and the switch box shall be locked. Safety is very important, so you should pay more attention when using this equipment for construction, and more relevant content will come to our website http://www.jiyini.cn Consult!